Rear Drum Brake Adjustment - 220Sb

1961-1968: a.k.a "Finnie" or "Heckflosse" models
190, 190D, 200, 200D, 220b, 220Sb, 220SEb, 230, 230S, 250SE coupe, 280SE coupe, 280SE 3.5 coupe, 220SEb cabrio., 250SE conv., 280SE cabrio., 280SE 3.5 Cabrio., 300SE, 300SE coupe, 300SE conv., 300SEL
Post Reply
User avatar
dynamike
S Class
Posts: 76
Joined: Thu 27 Oct, 2016 8:35 am
Model you own: w111
Location: Brisbane, QLD

Rear Drum Brake Adjustment - 220Sb

Post by dynamike » Mon 19 Jun, 2017 8:03 pm

So I replaced the left rear brake shoe on my 220Sb with that from my 220SEb donor car after the friction pad came off. The replacement sits too tight generating way too much heat and I need to adjust it.

Looking at the top row of the photo below that bolt very much looks like the eccentric bolt used to adjust it mechanically. Though I'm slightly confused as I expected the 220Sb to have the automatic adjustment?

Image

Also, the bottom photo shows the hexagonal bolt holding the brake shoes in place. This is how I found it but shouldn't the thick washer sit on the outside so the inner brake shoe sits right against the pressure spring on the anchor point?

Thanks,

Mike
1965 220 Sb Sedan
1962 220Seb Sedan (stripped for parts)
http://ozbenz.net/viewtopic.php?f=9&t=23626

User avatar
Bartman4800
300 SLR
Posts: 1817
Joined: Fri 10 Oct, 2008 12:10 am
Model you own: w111
Location: Perth WA

Re: Rear Drum Brake Adjustment - 220Sb

Post by Bartman4800 » Tue 20 Jun, 2017 3:08 pm

No, the finnie does not have automatic brake shoe adjustment.

Make sure those excentric bolts rotate freely ( but not loosely)
Rotate the excenter so that the shoes are fully in.
Install the drum, with a couple of wheel bolts so it is fully home.
Make sure the hand brake cable is loose.
Then adjust each shoe until it starts to hit. A little bit of drag is fine.
Check your hand brake, should rattle max. 7 notches. Adjust cable if necessary

I can't tell if that washers sits in the correct position, but your brake shoes should be parallel to the backing plate.

Bart
1963 220 Sb Sedan "Kermit" (Australian Assembly)
1960 220 Sb Sedan "Zum Schlachten" (Early German Assembly, with a torsion bar spring for the bonnet) - Stored in Country WA
1981 Subaru Brumby 1.8 with Weber and 5-speed box "little utie" - Sold to another enthusiast!
2006 Ford Focus "daily driver"
2002 VW Passat V6 30V Station Wagon (SOLD - This car into a money pit)
2011 Kia Sportage "Missus commuter Bus"
2002 Mitsubishi Rosa Bus (converting it to a motor home)

Post Reply

Return to “W110, W111, W112 Sedans, Coupes and Cabriolets.”