Jammed Heater Cables

1968 - 1976: 220, 220D, 230, 230.4, 230.6, 240D, 250, 250C, 250CE, 280, 280E, 280CE, 300D
Post Reply
LOW114
Dernburg Wagon
Posts: 7
Joined: Sat 27 Aug, 2016 8:28 am
Model you own: w114

Jammed Heater Cables

Post by LOW114 » Tue 11 Oct, 2016 6:14 pm

Hi,

Is there any DIY repair articles on jammed Heater cables? The Cooling controls work perfectly, just the heater is jammed.

I have heard sometimes it can be an easy fix but other times it can be painful, I'm hoping mines on the simple side [emoji16]



Sent from my iPhone using Tapatalk

oldmercfan
Pagoda
Posts: 141
Joined: Mon 24 Mar, 2014 7:32 pm
Model you own: w114
Location: Adelaide

Re: Jammed Heater Cables

Post by oldmercfan » Tue 11 Oct, 2016 10:20 pm

Hi, if your problem is the same as mine, it's not the cables that are jammed but the heater control valve attached to the bulkhead. These are made of brass and they corrode and jam up. The seals also wear out. The valve is easy to pull apart and clean up with a bit of fine sandpaper, and you can buy heater value kits very cheaply from the forum sponsor. I did this and the heater was wring perfectly, although a year later it is jamming up again. Maybe someone else can chip in here. Should I have out some grease in there when I replaced the seals?
1972 W114 280E (Tiefblau)
1986 W201 190E (White)

User avatar
Bartman4800
300 SLR
Posts: 1816
Joined: Fri 10 Oct, 2008 12:10 am
Model you own: w111
Location: Perth WA

Re: Jammed Heater Cables

Post by Bartman4800 » Wed 12 Oct, 2016 10:56 am

It's always good to put some O-ring grease (silicone grease, not vaseline) on when installing seals like that...

I bought a tube at the local O-ring shop (Transseals), but CBC, statewide bearings etc. should have it too.

Bart
1963 220 Sb Sedan "Kermit" (Australian Assembly)
1960 220 Sb Sedan "Zum Schlachten" (Early German Assembly, with a torsion bar spring for the bonnet) - Stored in Country WA
1981 Subaru Brumby 1.8 with Weber and 5-speed box "little utie" - Sold to another enthusiast!
2006 Ford Focus "daily driver"
2002 VW Passat V6 30V Station Wagon (SOLD - This car into a money pit)
2011 Kia Sportage "Missus commuter Bus"
2002 Mitsubishi Rosa Bus (converting it to a motor home)

Post Reply

Return to “W114 and W115”